TOYOTA LAND CRUISER
FJ45LV - FOUR DOOR WAGON

SPECIFICATIONS

TOYOTA MODEL
WHEELBASE..............................2,650mm (104.3in)
TREAD
`````FRONT.........................1,404mm (55.3in)
`````REAR...........................1,400mm (55.1in)
OVERALL LEGNTH..................4,660mm (183.4in)
`````WIDTH........................1,720mm (69.7in)
`````HEIGHT......................1,770mm (69.7in)
GROUND CLEARANCE..........210mm (8.3in)
HEADROOM.................................927mm (36.5in)
LEGROOM....................................1,092mm (43 in) front floor to front seatback
TRACK
`````FRONT...........................1,405mm (55.3in)
`````REAR..............................1,400mm (55.1 in)
WEIGHT
NET VEHICLE WEIGHT..........1,850kg (4,070lb)
SEATING CAPACITY...............3 or 6 persons
PAYLOAD....................................600kg (1,320lb) 400kg (880lb)

ENGINE
TOYOTA MODEL......................F gasoline
TYPE................................................6-cylinder in line. 4-cycle, pushrod O.H.V.
LOCATION....................................Front
BORE & STROKE........................90 x 101.6mm (3.54 x 4.00in)
PISTON DISPLACEMENT.......3878cc (236.7 cu in)
COMPRESSION RATIO.............7.5 (7.7 in 66-67?)
MAX GROSS HORSEPOWER...(SAE) 135 HP @ 3,800 rpm
MAX NET B.H.P............................125 HP @ 3,600 rpm
MAX GROSS TORQUE...............(SAE) 30 m-kg (217 ft-lb @ 2,000 rpm)
MAX NET TORQUE.....................29.0 m-kg (210 ft-lb @ 2,000 rpm)
ENGINE SERVICE WEIGHT......282kg (621.7 lb)
RECOMMENDED RED LINE....3,800-4,000 rpm
FIRING ORDER...............................1-5-3-6-2-4
4 bearing forged crankshaft
Aluminum alloy forged pistons
Deep skirt block webbed for extra rigidity
2 compression and 2 oil rings

FUEL SYSTEM
AIR CLEANER.............Oil bath type (Optional paper filter element type)
CARBURETOR............Down-draft, single barrel
TANK CAPACITY......70 liters (18.5 US gal.)
FUEL PUMP..................Mechanical diaphragm type driven off camshaft

COOLING SYSTEM
TYPE...............................Water cooled, forced circulation by centrifugal pump.
Spindle runs in sealed ball bearings which require no lubrication
Circulation controlled by thermostat
RADIATOR...................Fin and tube type
WATER CAPACITY...16.5 liters (4.3 US gal.)

LUBRICATION SYSTEM
TYPE...............................Full pressure force feed type by gear pump
OIL CLEANER.............Paper filter element type
OIL CAPACITY............6.5 liters (6.9 US qts.)

IGNITION
TYPE...............................12 volt coil
DISTRIBUTOR.............Centrifugal governor and vacuum spark controler

ELECTRICAL SYSTEM
BATTERY......................12 volts 50 amp. hr, (20 h.r.)
Negative ground, output regulated by Current Voltage Control System.
Double horns
Sealed type headlamps
Parking lamps and turn indicator lamps
Combined tail and stop lamps
Electrical type windshield wipers
GENERATOR................(1963, early ’64) 12 volts 216 watts
ALTERNATOR.............(1964 – 1967) 12 volts 360 watts (420 watt optional)
STARTING MOTOR....12 volts 1.4 HP

CLUTCH
TYPE...................................................Dry single plate with centrifugal weights and torsion rubbers
OPERATION....................................Pendant pedal, hydraulic release
FACING DIAMETER.....................275mm (10.8in)
FACING AREA...............................715cm² (111sq-in)

TRANSMISSION
TYPE...................................................3-speed, 2nd & 3rd gears synchromesh
GEAR RATIO
1st........................................2.76
2nd.......................................1.70
3rd........................................1.00
Reverse...............................3.67
GEAR LEVER POSITION.............Steering column (center floor optional?)

TRANSFER
TYPE......................................................2-speep, helical gear sliding type
GEAR RATIO
Low.......................................2.31
High.......................................1.00

DRIVESHAFT
TYPE......................................................2 – 1 piece, open tube

AXLE
FRONT
TYPE....................................Full-floating, hypoid gear drive
REDUCTION RATIO......4.11
CAPACITY.........................900kg (2,000lb)
REAR
TYPE....................................Semi-floating, hypoid gear drive
REDUCTION RATIO......4.11
CAPACITY.........................900kg (2,000lb)

SUSPENSION
FRONT...................................................Semi-elliptic leaf springs with hydraulic shock absorbers
REAR......................................................Semi-elliptic leaf with hydraulic shocks & torsion-bar type stabilizer

STEERING
TYPE.......................................................Worm and sector roller type
GEAR RATIO........................................21 to 1
TURNS......................................................4.5 lock to lock

BRAKES
SERVICE BREAK...............................Hydraulic brake, operating all wheels
DRUM DIAMETER............290mm x 55mm (11.4 in x 2.17 in)
BREAKING SURFACE....1,180 sq. cm (183 sq. in)
PARKING BREAK...............................Mechanical, operating on propeller shaft

WHEELS
TYPE.........................................................15x? steel, 5 lug

TIRE SIZE
FRONT......................................................7.00-15 6 ply
REAR.........................................................7.00-15 8 ply

FRAME
TYPE..........................................................Girder type, channel section

PERFORMANCES
MAX SPEED.............................................120km/hr (75mph)
MAX GRADE ABILITY......................34°
MAX TURNING RADIUS...................6.2 m (20.3ft)
ACCELERATION (2-aboard)
0-30 mph..................................4.6 sec
0-45 mph..................................12.0 sec
0-60 mph....................................22.3 sec
Standing start ¼ mile.............22.3 sec and 60 mph
SPEEDS IN GEARS @ 4,000 rpm
1st.................................................30 mph
2nd................................................50 mph
3rd.................................................74 mph (3,600 rpm)
MPH @ 1,000 rpm
3rd.................................................21.0 mph
STOPPING DISTANCES
30 mph........................................42 ft
60 mph........................................164.5

MAJOR OPTIONAL EQUIPMENT AT EXTRA COST
Wheel (hub) cap
Center cut out for hubs
Solid for driveplates
Warn hubs
Husky hubs
Factory/OEM power take-off and winch
Power take-off with shaft assembly (no winch)
Ramsey winch assembly (complete with cable)
Ramset power take-off with shaft assembly (no winch)
Ramsey P.T.O. only
Capehart fuel level control
Parts tour kit (fan belt, points, condenser, spark plugs, and oil filter)
Antifreeze
Mud and snow tires
Wrap around rear bumper
Pintle hook & trailer socket (not available on v & lv models with drop type rear doors)
Fog lamp
Defroster & car heater single or dual (available on left-hand steering models?)
Hadees Heater (model 781)
Eaton heater with defroster kit and fittings
Eaton heater with defroster, fresh air adapter and fittings
Car radio & antenna
Short wave adapter
7.60-15 6 ply tires (front and rear)
420 watt alternator (later 64-67)
Direct control type gearbox?
Starting handle (not available with front winch)
Cigar Lighter (standard on 66-67 under ash tray)
Windshield washer? (available on left-hand steering models?)
Seat belts
Spare fuel tank (Jerry can)
Fuel strainer

STANDARD EQUIPMENT other
Body undercoating
Floor mat and firewall insulation
Sun visors
Fuel tank lock (66-67 only)

Click here to open this page in it's own window